(3) Work the leather up so you expose the seat back. The heating element will be right there in the lower back section. Peel it off the cushion. (4) Follow the wires down under the seat and undo two plastic clips. (5) Stick the new element on and route the wires underneath and plug it back in. (6) Your seat heaters should work again. You can remove the cover in situ, unclip it from around the cables then along its length, its not easy but do able. If your not happy doing that, disconnect the battery, remove the connector then take off the cover, insert the connector, connect the battery. The cover can be replaced in situ. pgeddes79 Discussion starter. 35002 posts · Joined 2004. #1 · Dec 28, 2018. Hey there, Got a 2010 Corsa 1.2 SXi, and the heat direction dial will only move a few degrees from centre. Is this a common problem? Thought I would ask, before I start removing stuff and finding out if it's the panel or flaps etc further in to the heater box. This is an old Thermostat from Opel's XEP, XER, XEL enginer. It has heater which makes the thermostat to open sooner than 105 degrees designed.ECU heats it u 153 Answers. SOURCE: Vauxhall Astra 1.4 gsl (M - Reg) Have your blower motor resistor checked,this is the most likely solution. Posted on Oct 25, 2008. Anonymous. 1 Answer. SOURCE: heater does not blow hot air ,just mild warm air. Make sure the raditor is full. I have a 2012 Insignia 2.0 CDTI Sport Tourer with Single Zone Climate Control. This week the blowers have stopped working altogether, I've tried all the speeds as I read threads where the blowers work on level 4 but no others. This is not the case for me, the blowers do not work at all. I've checked the glove-box fuse and all is OK there. gashy. 581 posts · Joined 2006. #2 · May 13, 2017. It should be located behind the glove box on the right hand side next to the centre console. And held in by 2 torxs bolts. Look for 2 cables coming off the motor itself going into the resistor. If your handy with a soldering iron then pay around £1 for the resistor itself and solder it onto Vay Tiền Cấp Tốc Online Cmnd.

opel astra heater not working